How do you know if your golf cart is 36 or 48 volt?

Determining how many volts your golf cart uses is as easy as counting the water fill caps on all of your batteries. If you have six 6 volt batteries your golf cart is a 36 volt cart, if you have six 8 volt batteries or four 12 volt batteries your golf cart is a 48 volt cart.

How do I know what voltage my golf cart is?

To determine whether your golf cart is 36V or 48V, follow these steps:

1. Lift up the seat to view the battery compartment.
2. Count the number of holes on each battery. ...
3. Multiply the number of holes by 2 to determine the golf cart battery voltage.
4. Multiply the golf cart battery voltage by the total number of batteries.

What voltage is my golf cart battery?

Healthy batteries will indicate about 50 to 52 volts on the voltmeter. Most battery packs hold around 48 volts. Keep in mind that the high number doesn't mean that the batteries are instantly good. This measured value doesn't take the load or cart's power consumption into consideration.

How do I find out what kind of golf cart I have?

Club Car Golf Carts

1. Find your serial number. It will be under the dash on the passenger side.
2. Find your model code. The model code will be the first two letters of the serial number.
3. Find your year code. The year code will be the third and fourth character of the serial number.

Can you run a 36 volt golf cart on 48 volts?

It all depends on your battery bank used with this 36V to 48V conversion. can only be accomplished through installing a 48V motor capable of higher torque, or installing a 48V controller with a higher current limit (amperage).

What happens if you put 48V to a 36V motor?

It won't hurt it to try it. All the will happen is that the controller will shut down earlier if the cut off voltage is set for the 48v which might be right at 42v which would be peak on the 36v.

Can you put 3 12v batteries in a 36V golf cart?

If you have a 36-volt golf cart that runs on six 6-volt batteries, you can replace them with three 12-volt batteries, which often are easier to find.

How can I tell what year golf cart I have?

The serial number of each vehicle is printed on a bar code decal. The two letters at the beginning of the serial number "A" indicate the vehicle model. The following four digits "B" indicate the model year and production week during which the vehicle was built.

What motor does my Club Car have?

The gas model of the Club Car DS has a single-cylinder 286 CC engine that, combined with an overhead value of 60K, a pressure-lubricated design with air cooling, and a six-speed automatic transmission. Usually, they can make about nine quarts of beer. In just 3,600 rotation times, the engine produces 5 horsepower.

What's the difference between 36V and 48V?

Battery Volts

A 36V e-bike battery will allow you to draw a lesser critical current, typically around 15 amperes whereas, a 48V e-bike battery will allow more current in the range of 10 – 40 amperes. It means you can go faster with a 48V E-bike battery.

What voltage are EZ GO golf carts?

The electrical drive system powered for EZGo golf carts is either 36-volt or 48-volt. Some newer models are 72 volts. This requires a combination of multiple batteries in other to work properly.

What voltage is my battery?

How to Test Your Battery Voltage with a Voltmeter

1. Make sure your vehicle is turned off.
2. Remove the battery's positive terminal cover. ...
3. Check the reading. ...
4. Any voltage above 12.9 volts is a good indicator that your battery has excessive voltage. ...
5. Charge your battery if the voltmeter display a voltage below 12.4.

How many miles will a 36 volt golf cart go?

A 36 volt golf cart is adequate for 2 to 4 passenger use when you are primarily using it on flat a flat surface. The average drive time or range for a 36 volt DC system is about 30 miles on a full charge.

How many batteries do I need for a 36 volt golf cart?

A 36V EZGO cart will have 6 batteries with 3 holes on each battery. Each hole represents a 2 volt cell.

What motor is in a Club Car golf cart?

Club Car has installed a 286 cc, single-cylinder, overhead valve, pressure-lubricated and air-cooled engine on its gas-model DS Player. The horsepower for the gas model is 9.5 at 3,600 rotations per minute.

Is my golf cart series?

Does the Golf Cart have a Tow/Run switch or Run/Maintenance switch? This would be under the seat. If the cart DOES have this switch, it is a Regen (Regenerative Braking) cart. If there is NOT a switch, then its a Series cart.

What does Club Car DS stand for?

What does DS stand for in Club Car golf carts? The Club Car DS model type, in production from 1980 to 2014, was named after Dom Saporito, a vehicle designer at Club Car in the 1980s.

Where do I find the model number on my E-Z-GO golf cart?

The serial number and manufacturer's number for these E-Z-GO golf cart models can be found on a plate located under the glove box on the passenger's side of the vehicle. The serial number is either six or seven numbers and does not indicate the model year.

What is the difference between Club Car Precedent and DS?

The Club Car Precedent is the newest and most modern golf cart produced by Club Car. While the DS is still being built for some markets, the Precedent has taken over most of them. As a result, it has a broad array of features that separates it from the original DS.

Do golf carts have VIN numbers?

When scheduling service or ordering parts for your golf cart it is very important to know and locate the serial number (VIN). Each cart has its own unique serial number just like a car and by knowing what this number is you are able to determine what type, year, and power supply your cart has.

Can a 36v controller handle 48v?

Re: Will a 36 volt controller handle a 48 volt battery? Probably already stated and answered but a 36v controller will work on a 48v battery, its just the controller wont kick in for lvc.

Can I use car batteries in my golf cart?

Can You Use Regular Car Batteries in a Golf Cart? The short answer is yes. Standard car batteries are 12-volts, and you could connect three or four of them in series to provide the required 36 or 48 volts to your golf cart motor. However, the design of car batteries provides a huge surge of current for short periods.

Can I use regular deep-cycle batteries in my golf cart?

These batteries supply enough power for the golf cart to be used for an entire 18-hole round of golf. Golf carts can be modified to use 12-volt marine deep-cycle batteries, but this modification would not provide nearly the battery life as golf cart batteries.

Can I use 48V battery on 36V motor?

Re: Using a 48V battery pack with 36V motor/controller

Most 36V controllers will support a 48V pack, but the LVC will still be set for a 36V pack, so you'll need to monitor pack voltage and not let it get too low.